Vesicularity of individual pyroclasts from airfall tephra deposits is an important parameter that is commonly measured at basaltic volcanoes. Conventional methods used to determine pyroclast vesicularity on a large number of clasts has the potential to be time consuming, particularly when rapid analysis is required. Here we propose dynamic image analysis on two-dimensional (2D) projection shapes of crushed pyroclasts from tephra deposits as a new method to estimate vesicularity. This method relies on the influence of vesicles and uses grain morphology as a proxy for vesicle size and abundance. Pyroclasts from a variety of basaltic tephra deposits from the volcanoes of Mauna Loa and Kīlauea were analyzed. Vesicularities between 52–98% were measured via nitrogen-gas pycnometry. The same pyroclasts were then crushed and sieved, and their grain shapes measured using dynamic image analysis on a CAMSIZER®. This yields values for the mean sphericity, elongation, compactness, and Krumbein roundness of the grains. Our data show that grains become increasingly irregular with increasing vesicularity, with the degree of correlation between shape parameters and vesicularity depending on the size of measured grains. Shape irregularities in small grains (60–250 µm) are mostly area-based, with elongation being the best vesicularity indicator, whereas shape irregularities in large grains (250–700 µm) are mostly perimeter-based, with Krumbein roundness as the best vesicularity indicator. Using mean shape parameter values with all grain sizes included, grain elongation is the most well-correlated shape parameter with vesicularity, with the best fitted model explaining 76% of variation in the observations. Microscope images of thin sections of intact pyroclasts, as well as from crushed pyroclasts, were analyzed using CSDCorrections 1.6 software in ImageJ to find local vesicularity, vesicle size, grain size, grain elongation, and vesicle spatial distribution by stereological conversion. Observed correlation between grain shape and vesicularity can be explained by the local effect of vesicles on the shape of the solid structure in between those vesicles. Grain shape depends not only on vesicularity, but also on vesicle to grain size ratio and the spatial distribution of vesicles. The influence of vesicles on grain shape is best captured by grains with the size of the solid structure in between vesicles, which generally increases with decreasing vesicularity. Dynamic image analysis is a useful tool to quickly gauge vesicularity, which could be used in near-real-time during an eruption response. However, this method is best suited for highly vesicular (> 80%) basaltic pyroclasts from tephra deposits with few microlites and phenocrysts. Further research on crushing techniques, optimum grain size for shape measurements, and Krumbein roundness measurements for the grain size range of 250–700 µm might enable application of this method to lower vesicularity pyroclasts.